田宏亮,邹祖杰,郝世俊,等. 矿山灾害生命保障救援通道快速安全构建关键技术与装备[J]. 煤田地质与勘探,2022,50(11):1−13. DOI: 10.12363/issn.1001-1986.22.05.0415
引用本文: 田宏亮,邹祖杰,郝世俊,等. 矿山灾害生命保障救援通道快速安全构建关键技术与装备[J]. 煤田地质与勘探,2022,50(11):1−13. DOI: 10.12363/issn.1001-1986.22.05.0415
TIAN Hongliang,ZOU Zujie,HAO Shijun,et al. Key technologies and equipment of quickly and safely building life support and rescue channel in mine disaster[J]. Coal Geology & Exploration,2022,50(11):1−13. DOI: 10.12363/issn.1001-1986.22.05.0415
Citation: TIAN Hongliang,ZOU Zujie,HAO Shijun,et al. Key technologies and equipment of quickly and safely building life support and rescue channel in mine disaster[J]. Coal Geology & Exploration,2022,50(11):1−13. DOI: 10.12363/issn.1001-1986.22.05.0415

矿山灾害生命保障救援通道快速安全构建关键技术与装备

Key technologies and equipment of quickly and safely building life support and rescue channel in mine disaster

  • 摘要: 矿山发生重大灾害事故导致井筒、巷道破坏,人员被困井下时,通过安全、高效地构建救援通道是最有效的救援方式。救援通道包括井下、地面2种形式,井下具备施工条件时,构建穿过坍塌段的大直径救援通道,是最直接的方式;井下不具备施工条件或易发生次生灾害时,则需先在地面快速、精准钻进小直径搜救孔,确定井下被困人员位置及身体状况,并及时输送给养,再构建大直径救援井,采用专用救援提升装备保障被困人员升井脱困。研究涵盖机械工程、钻井工程、电气工程、软件工程、流体力学、岩土力学、动力学、先进控制技术等多学科多领域,将理论分析、数值模拟、实验研究、型式试验、工程示范相结合,以“救援通道构建装备研制—生命保障通道构建技术开发—大直径救援通道构建技术开发—地面提升救援装备开发—技术与装备集成及工程试验”为主线,开发钻孔救援关键技术与装备。研制了3套应急救援集成装备,ZMK5550TZJF50/120型救援车载钻机最大提升力1 200 kN、最大转矩50 000 N·m,开发了钻机与配套机具的一体化集中控制系统,单根起下钻效率小于3 min/根;XZJ5240JQZ30型救援提升车开发了多传感器信息融合的通信监测控制系统,提升系统最大救援深度848 m;ZDG1500型井下大直径顶管机直径1 630 mm,最大顶推力8 541.2 kN。开发了复杂地层生命保障孔快速、精准钻进技术,地面大直径救援井精准、安全、高效钻进及透巷技术,井下大断面救援通道顶管快速施工技术3项矿山应急救援通道构建技术。在宁夏宁煤梅花井矿开展了国内首次生命保障孔及大直径救援井施工、救援提升的集成研究和工程示范,完成井径215.9 mm、井深670.5 m生命保障孔,用时46.83 h,井底水平位移偏移0.27 m,满足72 h黄金救援时间内成孔要求;完成井径830 mm、井深654.1 m救援井,井底水平位移0.19 m,介质溃入井下约7.5 m³,并在救援井内成功进行了救援提升技术与装备试验。在广东省基础工程集团有限公司碎石场开展了顶管钻进工程模拟坍塌条件下的试验,施工长度102.5 m,日进尺43.92 m,顶进误差0.35 m。相关成果在湖南源江山煤矿、山东栖霞金矿、新疆丰源煤矿等5次矿山灾害应急救援中进行了应用。开发的3项救援通道施工技术及3套救援装备,构成了具有自主知识产权的矿山井上井下联合救援技术与装备体系,可满足600 m深度的矿山应急救援需求,为我国矿山灾害救援提供技术装备支撑。

     

    Abstract: In case that persons are trapped underground as a result of shaft and roadway damage due to a major disaster accident in a mine, the most effective way of rescue is to construct the rescue channel in a safely and efficient manner. The rescue channel is divided into the underground and ground types. Building a large diameter rescue channel through the collapsed section is the most direct way if underground construction conditions are available. However, if no underground construction conditions are available or it is prone to secondary disasters, it is necessary to drill small diameter rescue holes on the ground quickly and accurately to determine the location and physical condition of the trapped people underground, and deliver the supplies in time. Then, a large diameter relief well should be constructed to ensure that the trapped people can be pulled out of the well with the special rescue equipment. The research covers multiple disciplines in many fields such as mechanical engineering, drilling engineering, electrical engineering, software engineering, hydromechanics, geotechnical mechanics, dynamics, and advanced control technology. Meanwhile, the key technologies and equipment for drilling rescue were developed with the theoretical analysis, numerical simulation, experimental research, type test and engineering demonstration in combination, focusing on the main line of development of construction equipment for rescue channel, development of construction technologies for life support channel, development of construction technologies for large-diameter rescue channel, development of ground lifting rescue equipment, and integration and engineering test of technologies and equipment. Three sets of emergency rescue integrated equipment have been developed. ZMK5550TZJF50/120 rescue truck-mounted drilling rig has the maximum lifting force of 1 200 kN and the maximum torque of 50 000 N·m. The integrated centralized control system of drilling rig and supporting tools was developed, with the single tripping efficiency of 3 min/rig. In terms of XZJ5240JQZ30 rescue lifting vehicle, the communication monitoring and control system based on multi-sensor information fusion was developed, and the maximum rescue depth of the lifting system is 848 m. ZDG1500 downhole large-diameter pipe jacking machine has a diameter of 1 630 mm and the maximum jacking force of 8 541.2 kN. In addition, three construction technologies of mine emergency rescue channel were developed, including the fast and accurate drilling technology of life support hole in complex formation, the accurate, safe and efficient drilling and roadway penetration technology of large-diameter ground relief well, and the rapid construction technology of pipe jacking in underground large-section rescue channel. The first integrated research and engineering tests for the construction of life support hole and large-diameter relief well, as well as rescue lifting, were carried out in the Meihuajing Mine of Ningmei Coal in Ningxia Province. Specifically, a life support hole at a diameter of 215.9 mm and a depth of 670.5 m was constructed in 46.83 h, with a downhole horizontal displacement offset of 0.27 m, satisfying the drilling requirements of 72-hour “golden window” for rescue. A relief well at a diameter of 830 mm and a depth of 654.1 m was drilled with a downhole horizontal displacement of 0.19 m and the media collapsed into the hole about 7.5 m3. Besides, the technology and equipment for rescue lifting was successfully tested in the relief well. Moreover, the test of simulated collapse of pipe jacking drilling project was carried out in the crushing field of Guangdong Foundation Engineering Group Co., Ltd., with a construction length of 102.5 m, a daily footage of 43.92 m and a jacking error of 0.35 m. Further, the relevant results were applied in the emergency rescue of five mine disasters, including Hunan Yuanjiangshan Coal Mine, Shandong Qixiashan Gold Mine and Xinjiang Fengyuan Coal Mine. In general, the three construction technologies of rescue channel and the three sets of rescue equipment developed together form the combined construction technology and equipment system underground and aboveground of mine with independent intelligent property rights, capable of meeting the needs of mine emergency rescue at a depth of 600 m, thus providing technical and equipment support for emergency rescue of mine in China.

     

/

返回文章
返回